Chicago to Washington, D.C., on One Tank of Diesel

Passat_tdi

The maximum fuel range you see advertised on TV can be a myth.

Technically, the claimed range is accurate if you squeeze every last drop of fuel from the tank and are able to achieve a sometimes optimistic highway mileage. Doing so can also lead to standing on the side of the road after running out of fuel and discovering how acclimated the local wildlife is to humans.  
 
The diesel-powered 2013 Volkswagen Passat TDI has a massive advertised range of 795 miles, marked by a footnote reading, “Range based on 43 mpg highway EPA estimate and 18.5-gallon fuel tank for 2012 2.0L TDI, manual transmission. Your mileage will vary.” There's even a humorous ad about two guys learning Spanish on a road trip in the time it takes to run out of fuel in the Passat.

That 795-mile number is big. To give it some perspective, the distance from Chicago to Washington, D.C., is roughly 700 miles. It also happened to be the trip I used to test the Volkswagen Passat TDI’s range.

We know it’s "possible" to exceed the TDI’s range estimates based on a 1,526.6 trip one fuel-friendly couple took in a Passat TDI. However, my plan wasn’t to drive with hypermiling techniques, boost tire pressure above the factory recommendations or alter the car in any way for better mileage. I merged onto the expressway, set the cruise control to 70 mph and was on my merry way.

Letting the cruise control do the work resulted in a stunning 52.5 mpg average over the combined 1,452-mile trip. By the end of each leg, the seemingly endless 18.5-gallon tank wasn’t remotely close to being empty; there was an additional 130 miles of range left after my return trip.

IMG_1643
The journey wasn’t totally uneventful. My troubles revolved around filling up. Finding a station that sold diesel and then finding diesel that complied with the Passat’s warranty requirements proved difficult. The nearest diesel pump in Chicago had a warning stating the fuel could be 5-20% biodiesel, and the amount cannot be verified because the diesel wasn’t their branded fuel. The Passat TDI recommends a maximum 5% biodiesel blend to honor the warranty.
 
Finding diesel in an unfamiliar city also proved annoying until I downloaded Diesel Power magazine’s fuel-finder for the iPhone, a free application and invaluable addition to my trip. Unfortunately, the pump I filled up at didn’t click off automatically — apparently not uncommon with diesel pumps. The few gallons of diesel that spewed onto the ground before I realized what happened ruined my fill-up calculations for the first leg and added cost to the fill up. That station — unlike the second one I filled-up at — didn’t have plastic gloves to use while filling up, so my hands were oily and smelled like diesel after I frantically pulled the nozzle from the tank.     Photo2

Even with the overfill, the trip’s combined cost of fuel totaled a paltry $140.60. That’s a fraction of what I would have spent to fly two people from Chicago to D.C. Even the additional $80 I spent in round-trip tolls makes driving the Passat TDI to D.C. reasonable. If I had gotten the best highway mileage of the gas-powered 2.5-liter Passat base trim — rated at 31 mpg highway — it would have tallied a higher cost overall even with the lower price per gallon of regular unleaded. 

Granted, the trip took a combined 23.4 hours of driving time, but it was a scenic drive through Illinois, Indiana, Ohio, southern Pennsylvania and Maryland. Plus, the Passat is an amazing road tripper with a level of seating comfort and quietness that made the drive painless.

Passat_tdi_2

Chicago to DC
Time: 11 hours, 32 minutes
Trip computer mpg: 53.8 mpg
Fill-up calculation: NA from tank spillage
Trip miles: 713.1 miles
Average speed: 62 mph
Outside temp.: 74 degrees
 
DC to Chicago
Time: 12 hours, 9 minutes
Trip computer mpg: 51.2 mpg
Fill-up calculation: 51.7 mpg
Trip miles: 738.8 miles
Average speed: 61 mph
Outside temp.: 63 degrees

Related
2012 Volkswagen Passat Review
Extreme Commuting: Diesel vs. Hybrid
84 mpg?! Couple Break Mileage Record With Passat TDI

Comments 

jorge

You should try hybrid diesel unluckily they are not available in the US . Here is a link its in spanish : http://m.citroen.es/es/gama-citroen/citroen-DS5/

que

All four cylinder cars get great mileage on the highway. Drive this same car in city stop and go traffic and you'll get mileage in the mid 20s using smelly and expensive diesel fuel. The passat TDI also requires expensive urea fluid to run, another hidden irritation. I recently drove the passat TDI and liked the way it rode, but the noise was very objectionable. Diesel clatter combined with injector ticks made the ride very unpleasant.

Jamie

que, diesel is not smelly. That's why it's called clean diesel. In a lot of places, it's the same price or cheaper than premium gas. Urea is only around 10 bucks every 10,000 miles. And also, if you get mid 20s on average in a TDI (city) you're doing something wrong.

que must have owned one of those old 1980s GM diesel I've read about...

jesse

Diesel fuel is 65 cents per gallon more expensive than regular gas. Only a fool would pay more for a stinking slow diesel vw when the hybrids are whats happening now.

Jordan L

Its no wonder diesel won't catch on in America. Ignorant customers and lack of infrastructer. Its unbelievable to think that a gas station in this day and age doesn't carry proper diesel. And to those who think diesels are stinky, dirty and slow. Crawl out from under your rock. New diesels are very clean and very powerful.

Ike G.

Well, I have to tell you guys that Diesel doesn't necessarily give you great mileage.

Small engines give you better mileage than bigger ones do, and in many places I frequent Diesel costs a lot more than gasoline.

I drive a 2009 F350 Diesel and the mileage I get, loaded or unloaded, is around 14mpg on the highways of Oklahoma.

When I rent a Peterbilt to haul hay and feed on a flatbed, the mileage I get, loaded or unloaded, is around 12mpg traveling through OK, KS, NB, NM, CO and TX.

If you keep your foot in that Passat TDI I bet you could burn a lot more Diesel than they did on this trip.

Glenn

My 2012 VW Sportwagen TDI is getting 37 mpg around town so far, and I am not afraid to use the torque to get in front of the turtles. Sorry Ike G., your theory is wrong for this turbodiesel! And as for Jesse, diesel may cost a little more, but on average diesel engines get 30% more mpg than a regular gasoline equivalent. My new Sportwagen not only is able to haul a lot of cargo and haul some butt, it also gets great mpg and VW diesels usually last 300,000 miles plus.

Post a Comment 

Please remember a few rules before posting comments:

  • If you don't want people to see your email address, simply type in the URL of your favorite website or leave the field empty.
  • Do not mention specific car dealers by name. Feel free to mention your city, state and brand.
  • Try to be civil to your fellow blog readers. This blog is not a fan or enthusiast forum, it is meant to help people during the car-buying process and during the time between purchases, so shoppers can keep a pulse on the market.
  • Stay on topic. We want to hear your opinions and thoughts, but please only comment about the specified topic in the blog post.
view posting rules

If you have a TypeKey or TypePad account, please Sign In

Search Results

KickingTires Search Results for

Search Kicking Tires

KickingTires iPhone App
Ask.cars.com